①在一個洗衣循環后應清理一下紐扣收集器,以減小泵的負擔，防止泵堵塞，延長泵的壽命。每三次洗衣循環后，應清理纖毛收集器，以提高烘干時風的流量，縮短烘干時間。減少纖毛在回收冷凝器上的附著，降低對回收冷凝器的腐蝕；
③隨時檢查過濾器的工作壓力,當壓力達到或超過1.5－2KG/平方厘米時,應清理過濾器.才降低泵的出口壓力而延長泵的壽命，每蒸餾5－8次,清理一次蒸餾箱.從而提高蒸餾速度,同時也減少污泥對底板的腐蝕，達到延長蒸餾箱壽命的目的；
①檢查水洗機皮帶的緊張力,以保證正常的洗滌轉速和甩干轉速，查看皮帶磨損情況，適時更換。檢查滌滌溶劑的PH值,如果發現PH值降低，應及時調整以防止干洗機的腐蝕，從而延長干洗機的壽命。
②徹底清理機器各處的纖毛，防止纖毛堵塞空氣道，減少纖毛吸附的污物對機器的腐蝕；檢查各個疏水閥的性能,并清理蒸汽管路和冷卻水管路上的過濾器以提高機器效率、節約能源。檢查并清理溶劑泵，防止堵塞在泵內的污物磨損泵的葉輪,并使泵的出口壓力提高，損壞密封件。
First of all, is to pay attention to the daily maintenance:
In a washing cycle after the clean up button collection, in order to reduce the burden of pump, prevent pump, extended pump life. For every three washing cycle, should clean up cilia collector, in order to improve the drying wind flow, shorten drying time. The reduced cilia in recovery condenser on the attachment, reduces to the recovery condenser corrosion;
The daily check three pneumatic component, the water discharge to prevent moisture from entering the electromagnetic valve and air valve, makes them early damage. When the oil level is insufficient lubricating oil, to ensure that each bearing lubrication sufficient, prolonging service life of a bearing.
③always check the filters work pressure, when the pressure reaches or exceeds1.5 2KG/ cm, should clean the filter. To reduce the pump outlet pressure and prolong the life of each distillation,5- 8, clearing a distillation box so as to improve the rate of distillation, but also to reduce the sludge on the bottom of the corrosion, reach to extend the life of the distilling box;
In two, the second is to make stage maintenance ( usually every month for a stage ):
①check washing machine belt tension, to ensure the normal washing speed and drying speed, view the belt wear, timely replacement. Check Di Di solvent pH pH value decreased, if found, should be adjusted in time to prevent the washing machine corrosion, thereby prolonging the service life of dry cleaning machine.
The thorough cleaning machine all cilia cilia, prevent blocking air channel, reduce cilia adsorption of dirt on machine corrosion; check the hydrophobic valve performance, and clean steam pipeline and cooling water pipeline filter in order to improve the efficiency of the machine, saving energy. Check and clean the solvent pump, preventing clogging in the pump in the dirt and wear the impeller of the pump, and the pump outlet pressure is increased, the seal is damaged.
In three, annual maintenance work also nots allow to ignore. (annual washing machines need thorough maintenance below):
①thoroughly clean the attachment in the coil pipe, heating coil and the airflow passage cilia, to improve drying recovery efficiency, reduce the corrosion of the dirt on the machine.
The discharge and clean the oil water separator, so as to ensure the normal separation of oil and water.
The distillation condenser cleaning and related lines, preferably with baking soda and water washing, dry cleaning oil to neutralize acid, prolong the service life of the machine.
The thorough cleaning solvent tank, will be deposited in the bottom box dirt thoroughly cleaned, to ensure that the dry cleaning oil quality, prolong the service life of the machine.
浙公網安備33010602010414號